|
|
|
Build a Stone Wall with Round Stones & Cement by Vicky Smith
|
|
|
Build a Stone Wall with Round Stones & Cement |
|
|
|
Business
|
|
The graceful curving lines of a stone wall evoke a sense of elegance and romance that few other man-made structures can match. Although most long-lasting stone walls are composed primarily of large, flat stones that stack well, you can build a stone wall with round stones as long as you mortar them together. Save money on purchasing premade mortar by mixing your own, which you can create by blending three parts of sand with one part of masonry cement, according to Plymouth Quarries, a stone quarrying company that has been in business since 1811. Instructions as follows: Firstly, determine the height, width and length of your wall. Try to limit the height of your stone wall to less than 3 feet in order to stabilize the wall and help keep the round stones from putting too much pressure on the mortar that binds them together. As a general rule of thumb, plan on constructing a wall that is approximately half as wide as it is tall; for example, if your wall is going to be 18 inches tall, then it should be at least 9 inches wide. Secondly, collect the round stones for your wall. Look for stones that are at least twice as large as your hands clasped together. Avoid any that are perfectly round since they're more likely to compromise the strength of your wall. If you're gathering stone from your own property, check creek beds for gently rounded, elongated garden stones that should work well to stabilize your wall. Thirdly, pound metal rebar posts into the ground with a hammer to mark the corner and end locations of your stone wall. Tie a string to one of the posts and run it tightly between the rest of the posts to mark the front (face) of your stone wall. Fourthly, dig your footer trench along the entire length of the marking string. The trench should be at least 12 inches wider than the base of your wall; for example, if your wall is 18 inches wide, then the footer trench should be 24 inches wide. Extend the depth of the trench to the frost line in order to minimize cracking in your wall during yearly freezing cycles; if you're unsure what the frost line is in your area of the country, contact your county cooperative extension office. Fifthly, fill the footer trench with concrete. Level the concrete off approximately 1 inch below the soil line using a two-by-four board. Let the concrete cure for at least two to three days. Sixthly, mix your mortar with water in a wheelbarrow. Add enough water for the mortar to achieve a clay-like consistency. Dab the mortar on the concrete footer in a 1-inch layer. Select the largest, least round cubic stones for the base course to provide a solid framework for the rest of your wall. Press the stones firmly into the mortar, positioning them as close together as possible. Seventhly, build the rest of your stone wall one layer at a time. Spread the mortar in small sections and fit the stones together, staggering the joints between the layers to further strengthen the wall. Angle the stones toward the center of the wall to help stabilize it. Eighthly, scoop out excess mortar from between the exposed stone joints with a thin piece of scrap lumber. Remove dried mortar smears from the faces of your stones using a wire bristle brush. Tips & Warnings Check with your city office about obtaining any necessary permits before beginning construction on your wall. Avoid lifting large stones to minimize possible back injuries. Finally, let me have a conclusion. As an outstanding business E-platform of promoting stone industry, we are in possession of a powerful technology group and high-efficiency operations management system. If you want to consult us freely, you can also see diamond or become a loyal follower of us by @ https://twitter.com/stonebtb.
Related Articles -
diamond, stone walls,
|
Rate This Article |
|
|
|
Do you Agree or Disagree? Have a Comment? POST IT!
Reader Opinions |
|
|
|
|
|
|
|
|
Author Login |
|
|
Advertiser Login
ADVERTISE HERE NOW!
Limited Time $60 Offer!
90 Days-1.5 Million Views
|
|
TIM FAY
After 60-plus years of living, I am just trying to pass down some of the information that I have lea...more
|
|
|
|
|
LAURA JEEVES
At LeadGenerators, we specialise in content-led Online Marketing Strategies for our clients in the t...more
|
|
|
|
|
ALEX BELSEY
I am the editor of QUAY Magazine, a B2B publication based in the South West of the UK. I am also the...more
|
|
|
|
|
GENE MYERS
Author of four books and two screenplays; frequent magazine contributor. I have four other books "in...more
|
|
|
|
|
SUSAN FRIESEN
Located in the lower mainland of B.C., Susan Friesen is a visionary brand strategist, entrepreneur, ...more
|
|
|
|
|
STEPHEN BYE
Steve Bye is currently a fiction writer, who published his first novel, ‘Looking Forward Through the...more
|
|
|
|
|
SHALINI MITTAL
A postgraduate in Fashion Technology. Shalini is a writer at heart! Writing for her is an expression...more
|
|
|
|
|
ADRIAN JOELE
I have been involved in nutrition and weight management for over 12 years and I like to share my kn...more
|
|
|
|
|
JAMES KENNY
James is a Research Enthusiast that focuses on the understanding of how things work and can be impro...more
|
|
|
|