|
|
 |
|
|
Install Artificial Rock by Vicky Smith
|
|
|
Install Artificial Rock |
|
|
|
|
|
Business
|
|
|
Artificial rock can be installed on any surface that will bear the weight of the artificial rock and mortar. Many types of artificial rock exist; they are usually made made by molding a mixture of cement, iron oxides and lightweight aggregates to recreate the look of natural stone. Preparation procedures for installation of artificial stones depend upon the building material of the surface intended to be covered. Concrete and masonry walls require no special preparation. However, metal or wood require the installation of a weather-resistant barrier and metal lath and the application of a scratch coat of mortar. Instructions as follows: Firstly, attach a weep screed, using galvanized nails, 4 inches above grade or 2 inches above pavement. Check that the weep screed is level, as this is the starting point for your artificial stone installation. Secondly, attach a weather-resistant barrier to wooden or stone walls using galvanized staples. Overlap edges of the weather-resistant material 6 inches at the vertical edges and 2 inches at the horizontal edges. Ensure that the weather-resistant material laps around corners at least 16 inches; a double layer of weather-resistant barrier is preferred. Thirdly, staple metal lath to the wall with galvanized metal staples or nails, installing the metal lath so that the grooved cups of the expanded metal lath are turned upward. Overlap the lath 2 inches at vertical edges and 1 inch at horizontal edges. The metal lath should overlap corners by at least 16 inches. Fourthly, pour mortar into a wheelbarrow and add a small amount of water. Mix with your mortar-mixing hoe, adding water until the desired consistency is reached. Mortar should not be too wet or too dry or it will not stick properly to the expanded metal lath. The mortar should stick to a trowel that is turned sideways, but should fall off with one shake of the trowel. Fifthly, apply mortar to the expanded metal lath with a trowel, pushing the mortar into the lath and creating a layer 1/2-inch to 3/4-inches thick. Sixthly, scratch the surface of the mortar horizontally with a stucco rake after the mortar has begun to set. Allow to dry. Seventhly, lay artificial stones out on a flat surface to prepare for placement on the wall, using contrasts to create a visually appealing stone wall. Put thicker stones next to thinner culture stones larger stones next to smaller stones, and smoother stones next to rougher stones. Eighthly, pour dry ingredients of Type N mortar into wheelbarrow or mortar mixer. Add iron oxide for color tinting, if desired. Mix dry ingredients. Add water, a small amount at a time until mortar is the desired consistency. Ninthly, apply mortar to the back side of each artificial rock and press into place or apply mortar directly to the wall, covering approximately 5 feet of wall at a time. Place corner stones first. Alternate artificial rock corner stones so long and short sides are alternated. Tenthly, fill a mortar-grout bag with mortar that is wetter than mortar used for troweling. Eleventh, squeeze mortar into grooves around stones. After the mortar begins to set, use a pointed wooden stick or a small trowel to remove excess mortar. Brush the entire surface with a whisk broom to remove loose mortar and smooth the mortar surface. Tips & Warnings Check your local government zoning office before installing an artificial rock fence. Many areas have strict zoning laws regulating the type, size and height of fences. In short, as a popular business E-platform of promoting stone industry, we are the world leading portal website in stone industry. It mainly provides professional services of Internet application such as B to B E-commerce and network marketing for stone manufacturers and traders all over the world. If you want to consult us freely, you can also see travertine tile or become an honest follower of us by @ https://twitter.com/stonebtb.
Related Articles -
artificial stone, kitchen,
|
Rate This Article  |
|
|
|
|
|
Do you Agree or Disagree? Have a Comment? POST IT!
| Reader Opinions |
|
|
|
|
|
|
|
|
|
| Author Login |
|
|
 |
Advertiser Login
ADVERTISE HERE NOW!
Limited Time $60 Offer!
90 Days-1.5 Million Views
|
|
LEVAL AINAH
I am an internet marketer and also an educator. My goal is to help others who are looking to improve...more
|
|
|
|
|
STEPHEN BYE
Stephen Bye is a fiction writer. His most recent novels are a 5-book “The Developer” series which be...more
|
|
|
|
|
TIM FAY
After 60-plus years of living, I am just trying to pass down some of the information that I have lea...more
|
|
|
|
|
GENE MYERS
Author of four books and two screenplays; frequent magazine contributor. I have four other books "in...more
|
|
|
|
|
ADRIAN JOELE
I have been involved in nutrition and weight management for over 12 years and I like to share my kn...more
|
|
|
|
|
LAURA JEEVES
At LeadGenerators, we specialise in content-led Online Marketing Strategies for our clients in the t...more
|
|
|
|
|
MICHAEL BRESCIANI
Rev Bresciani is the author of two Christian books. One book is an important and concisely written b...more
|
|
|
|
|
PAUL PHILIPS
For more articles, blog messages & videos and a free e-book download go to www.NewParadigm.ws your p...more
|
|
|
|
|
ALEX BELSEY
I am the editor of QUAY Magazine, a B2B publication based in the South West of the UK. I am also the...more
|
|
|
|
